Credov's researched list of the 3 faults the Suzuki Jimny JB74 is known for, 3 of them serious or costly. Each one says what to look for when you check the car, so you can spot it before you buy. Not every car has these faults: they are the ones worth checking on this model.
What to look for: Hit a bump at 60-80 km/h and feel for the steering wheel shaking side to side.
Why it matters: This generation's factory damper means a shimmy is not normal and points to a worn or incorrectly set-up front end that a dealer has sometimes only partly fixed by replacing kingpins, with the wobble returning within a few thousand kilometres.
Typical repair: NZ$200–NZ$1,500 in New Zealand · A$210–A$1,550 in Australia
What to look for: Lie under the car and check the chassis rails and diff housings for flaking or scaling rust.
Why it matters: Flaking or scaling rust on the chassis rails or diff housings is structural wear starting unusually early for the car's age, so a cheap-looking car near the coast can need chassis work sooner than its distance travelled would suggest.
Typical repair: NZ$300–NZ$4,000 in New Zealand · A$310–A$4,120 in Australia
What to look for: Shift quickly between 1st, 2nd and 3rd from cold and feel for crunching going into 2nd.
Why it matters: A synchro that is already crunching into 2nd can take 2nd and reverse gear with it, turning a synchro repair into a full gearbox rebuild, and Suzuki has reportedly refused some warranty claims on cars fitted with diff lockers.
Typical repair: NZ$2,500–NZ$6,000 in New Zealand · A$2,580–A$6,180 in Australia
Got a question about a Suzuki Jimny JB74? Ask Credov: a noise, a warning light, a part or how to fix it.
On top of the faults above, every Credov inspection covers the basics: fuel smell, leaks or filler rust, engine oil leaks, power steering fluid leak, drive belt cracks or squeal, rust underneath: chassis and mounts, engine mounts, engine oil level and colour, coolant level, colour and leaks, head gasket failure signs, cold start: rattle, knock or smoke, rough or hunting idle, engine running hot on gauge, gearbox or diff oil leak, swapped gearbox without lvv and more.
Researched by Credov from manufacturer recalls and service bulletins, owner reports and workshop sources. Repair prices are typical ranges, not quotes. See also fault codes and repair costs.